---===SME_1310_00002_0001.djvu===--- chassis Supplement Pub.No.00ELB0017, SEPTEMBER 2013 Shop Manual ( EURO V ) 2013 Minor Change ---===SME_1310_00002_0002.djvu===--- ---===SME_1310_00002_0003.djvu===--- Pub.No.00ELB0017, SEPTEMBER 2013 ---===SME_1310_00002_0004.djvu===--- GROUP INDEX MODIFICATION SUMMARY ............ GENERAL ........................................ CLUTCH ........................................... TRANSMISSION <M038: DUONIC> ........................... TRANSMISSION <M038> ................ DUONIC ........................................... PROPELLER SHAFT ....................... FRONT AXLE <INDEPENDENT> ... REAR AXLE ..................................... WHEEL AND TIRE ........................... FRONT SUSPENSION <INDEPENDENT> ............................ REAR SUSPENSION ....................... ANTI-LOCK BRAKE SYSTEM (ABS) ................................ PARKING BRAKE............................ STEERING <RACK AND PINION> ..................... HEATER AND AIR CONDITIONER ......................... BODY ............................................... FOREWORD This Shop Manual is published for the information and guidance of personnel responsible for maintenance of Mitsubishi Fuso ROSA series buses, and includes proce- dures for adjustment and maintenance services. We ear- nestly look forward to seeing that this manual is made full use of in order to perform correct services with no wast- age. As this Shop Manual is published as a supplement to the following Shop Manuals, please refer to the followings for information not included in this manual. Chassis ROSA BE6. BC6 ........... Pub. No. TWSE0329 For more details, please consult your nearest authorized Mitsubishi Fuso dealer or distributors. Kindly note that the specifications and maintenance ser- vice figures are subject to change without prior notice in line with improvement which will be effected from time to time in the future. SEPTEMBER 2013 Applicable models BE ©2013 Mitsubishi Fuso Truck & Bus Corporation Printed in Japan ---===SME_1310_00002_0005.djvu===--- This Shop Manual contains the information classified into the following groups. If any system or equipment has two or more variations with significantly different construction, the variations are handled as different groups. These groups are identified by different alphabets preceded by the same number. 1. ENGINE volume (Pub.No.00ELB0016) 2. CHASSIS volume (supplement) (Pub.No.00ELB0017) 3. ELECTRICAL volume (Pub.No.00ELB0018) Group No. Group subject 00 GENERAL 11 ENGINE 12 LUBRICATION 13 FUEL AND ENGINE CONTROL 13E ENGINE CONTROL 14 COOLING 15 INTAKE AND EXHAUST 17 EMISSION CONTROL 17E DPF (Diesel Particulate Filter) SYSTEM Group No. Group subject MODIFICATION SUMMARY 00 GENERAL 21 CLUTCH 22A TRANSMISSION <M038: DUONIC> 22B TRANSMISSION <M038> 22E DUONIC 25 PROPELLER SHAFT 26B FRONT AXLE <INDEPENDENT> 27 REAR AXLE 31 WHEEL AND TIRE 33B FRONT SUSPENSION <INDEPENDENT> 34 REAR SUSPENSION 35E ANTI-LOCK BRAKE SYSTEM (ABS) 36 PARKING BRAKE 37B STEERING <RACK AND PINION> 55 HEATER AND AIR CONDITIONER 63 BODY Group No. Group subject 54 ELECTRICAL ---===SME_1310_00002_0006.djvu===--- 1 MODIFICATION SUMMARY ---===SME_1310_00002_0007.djvu===--- 2 This section describes the differences from "Shop Manual chassis ROSA BE6. BC6" (Pub.No.TWSE0329). Be sure to check the differences described in the following before servicing. Group Contents of different points Service procedure HOW TO READ THIS MAN- UAL (1) "HOW TO READ THIS MANUAL" is changed. See Gr00. 00 (1) "MODEL CODING SYSTEM" is different. See Gr00. (2) "POWER TRAIN TABLE" is different. (3) The engine number is different. (4) The following are added to "PRECAUTIONS FOR MAINTENANCE OPERATION". Handling of Battery Precautions When Repainting Precautions When Handling a Vehicle with DUONIC System Precautions on Cleaning When Servicing the Engine and Transmission (5) "JACKING UP THE VEHICLE" is added. (6) "DIAGNOSIS CODES" is added. (7) "TABLE OF STANDARD TIGHTENING TORQUES" is different. 21 (1) Clutch is different. See Gr21. 22A, B (1) Transmission is different. See Gr22A, B. 22E (1) DUONIC is added. See Gr22E. 25 (1) Propeller shaft is different. See Gr25. 26B (1) In "STRUCTURE AND OPERATION", Wheel Hub and Rotor, Knuckle is changed. See Gr26B. (2) "TROUBLESHOOTING" is added. (3) In "ON-VEHICLE INSPECTION AND ADJUSTMENT", Inspection of Wheel Bearing for Play is added. (4) "WHEEL HUB AND ROTOR, KNUCKLE" is changed. 27 (1) In "STRUCTURE AND OPERATION", Wheel Hub and Brake Drum is changed. See Gr27. (2) "ON-VEHICLE INSPECTION AND ADJUSTMENT" is added. (3) "WHEEL HUB AND BRAKE DRUM" is changed. 31 (1) "WHEEL AND TIRE" is different. See Gr31. 33B (1) FRONT SUSPENSION <INDEPENDENT TYPE> is different. See Gr33B. 34 (1) REAR SUSPENSION is different. See Gr34. 35A (1) Specifications for Vacuum Pump are different. Same as be- fore except these explained here. Item Specifications Type Radial blades type Output cm 3 /rev. 150 MODIFICATION SUMMARY ---===SME_1310_00002_0008.djvu===--- 3 35A (2) Vacuum pump is different. The vacuum pump (depressor), with radial blades, is also incorporated in the gear of oil pump with built-in depressor (GPOD). It is driven directly by the oil pump. (See Gr11.) Same as be- fore except these explained here. 35E Anti-lock brake system (ABS) is different. See Gr35E. 36 Parking brake is different. See Gr36. 37B (1) Specifications for power steering oil pump are different. Same as be- fore except these explained here. Group Contents of different points Service procedure Item Specifications Manufacturer FIAT POWERTRAIN TECHNOLOGIES Type Vane type Delivery rate cm 3 {mL}/rev. 11.5 {11.5} Adjusted flow volume dm 3 {L}/min. 6to8{6to8} Adjusted pressure (relief valve) MPa {kgf/cm 2 } 11.0 {112 } Permissible revolutions rpm 500 to 4900 0 --1 0 --10 ---===SME_1310_00002_0009.djvu===--- 4 37B (2) Power steering oil pump is different. • The power steering pump incorporated in the engine block generates hydraulic pressure for steering assistance. The pump is driven by the engine via the timing gear chain. • The power steering pump cannot be disassembled. To remove and reinstall it, see Gr11. -- (3) Power steering system is different. -- Group Contents of different points Service procedure MODIFICATION SUMMARY ---===SME_1310_00002_0010.djvu===---